Author Topic: Something rather Wrong!! (Read 5589 times)

Zhi · « **Reply #15 on:** December 22, 2005, 05:10:35 PM »

1) check and make sure the choke is not stuck on.
2) check and make sure the throttle cable is adjusted correctly and nothing else is pushing on it.

ReApEr66 · « **Reply #16 on:** December 22, 2005, 05:21:13 PM »

Thats what my mechanic did,
and told me something about the choke can freeze up or something,
But it happens then the bike is warm aswell as cold.

i will have to see tomorrow morning if it plays up again.

have to get up an hour early just incase it does screw up and i have
to get a lift in

( yes im lazy )

echomadman · « **Reply #17 on:** December 23, 2005, 07:16:26 AM »

Quote from: "ReApEr66"

Hmmmm...................

checked the idle, its fine, and its ok sometimes,
it has its tantrems when im turning around or something it kicks up in the revs

this sounds like your throttle cable is being snagged on something as you turn.
check that its routed properly.
Do you have the stock handlebars or aftermarket ones? you might need to have a longer throttle cable made up if you have aftermarket bars that are higher/wider than stock.

ReApEr66 · « **Reply #18 on:** December 23, 2005, 02:46:04 PM »

I have renthal style bars, im looking at replacing them with proper renthals
as the person who did the job on these ones wasnt very good,
and the controls move about a bit,

Will run through the cable tomorrow turning the handlebars,
the cable does sit abit 4" higher then it did with the old clip-ons,

it does it while standing still aswell is what gets me , i start it up
and it goes up in the revs, then i stop it move it to the position i wona go in
and start and go, and its fine, if i leave it to warm up a bit it will just rev its
***s off......

pmackie · « **Reply #19 on:** December 24, 2005, 03:24:48 PM »

What you are describing now sounds like an air leak problem. High idle and surging. Or your ilde circuit/air screws need adjusting.

Start by checking carb and intake manifold mounting bolts and look for cracks or problems with the manifold. Then check your air screw settings. Also, take your air cleaner out and look at it. Is it OK? or does it need cleaning or replacing?

ReApEr66 · « **Reply #20 on:** December 28, 2005, 04:07:56 PM »

it seems to be fine now, its just a bit cold weather that is bothering it now,
as it cuts out at every traffic light or when i stop
without holding the revs up...

getting a new thorttle cable / crank case covers / new headlamp ( as mines about as bright as a crappy torch from ASDA )
and hopefully a new clutch cable.. off my mates bandit ( which has a TL1000 clutch cable on it, if that makes a differance )