Author Topic: air box full of gas need help (Read 4664 times)

the kid · « **on:** July 02, 2007, 11:40:07 PM »

so my bike wasnt funning good so i pulled the tank. i couldnt find nothing wrong so i put it back to gether and rode it home and parked it for a while it sat for three or four days while i worked on my jeep. i kept smelling gas but really didnt think about it. well i went to go for a ride and the gas smell is the bike so i tore it all apart and the air box was full of gas whay could cause this. thanks

okbandit · « **Reply #1 on:** July 03, 2007, 08:41:29 AM »

Crankcase will be full of gas too. Oil change immediatly. You didn't list what bike you have, so I will assume it is a second gen with a vacuum operated petcock. The petcock leaked or was left on the PRI setting (prime) combined with a leaking needle and seat in at least one carb, which is not that uncommon, you get a soaked airbox, usually the air filter, and a crankcase full of oil and fuel mix. Beware that you may have a cylinder full of fuel as well. Pull the plugs before you crank it over and BE CAREFUL not to catch it on fire (isolate the spark plugs). If you have an earlier bike turn off the petcock when you park it and consider a carb cleaning soon.

the kid · « **Reply #2 on:** July 04, 2007, 01:16:03 AM »

thanks for the help its a 1996 b6 i did leave it on prime opps will i need to change the filter to i just did an oil change

okbandit · « **Reply #3 on:** July 04, 2007, 09:01:18 AM »

It would be best, since you ran it a little before tearing it down, remember that oil in our motors serves the function of cooling the motor as well, so clean good oil and filter are very improtant to the air oil cooled motors. In the future you have a drain tube for the air box at the bottom of the bike, it's a hose with a plastic plug in it. Could save you some time (drain when you change the oil as it usually has a little oil and water in the hose).